Preparations Knelson series concentrator installing and working principle
About electricity safety
Three phase power supply is used in the system, which may be dangerous to human body
It needs to be very careful on worktime.
A. regularly check whether the terminal is in good touch
B. If a damaged electrical component is found, the element should be isolated before repair or replacement
C. check the electrical box is sealed to prevent water
D. only allow qualified electrical technicians to carry out maintenance work
About concentrator
A. please do not put tools, screws and other electrical appliances placed on the pump, so as not to cause an electric shock hazard
B. make sure that all the pipes are adequately secured and supported. Check the valve after opening the system to ensure that all valves are normally closed
Start up&shutdown
Check the system before the start of the total power supply, water is normally open or not, shut down while all the system's power is off, water, other operations must comply with the open and shut down procedures to ensure the safety of the staff
Passageway
Adequate access and lighting shall be provided around the equipment for safe operation and maintenance
Ensure all operators are familiar with the safety issues related to the equipment
Be familiar with all pumps and valves,ensure smooth and adequate lighting around the facility
Working principle
Gold centrifuge is enhanced gravity centrifugal gold equipment based on the principle. In the high times enhanced gravity field, gravity difference proportion and the proportion of small mineral is greatly enlarged, which makes the separation of heavy minerals are more easily than the natural gravity field; and the material bed special design of retaining structure, the flow of water patented technologies and interaction of interference settling down, can continue to maintain a loose state. Under the above conditions, heavy mineral particles can replace the light mineral particles occupy in the sorting bed position and retained, light mineral particles as tailings are discharged, so as to realize the mineral particles by gravity separation.
Gold centrifuge in the production operation, the acceleration of gravity acceleration up to 60 times the enrichment cone or higher, when the pulp into the enrichment cone bottom, effect of slurry under the centrifugal force was thrown to the inner wall of the cone enrichment, and along the inner wall of the upward movement, at the same time by the water inlet hole cone continuous enrichment to make the bed in the cone of injection flow fluidization. In the action of centrifugal force and hydraulic recoil under radial resistance of single gold and other heavy mineral particles can overcome water, centrifugal sedimentation or drilling gap settlement in the bed. While the gangue mineral concentrate because of the less affected by centrifugal force, hydraulic recoil effect hard to overcome the axial force in the axial flow force and centrifugal force Together to promote the discharge of enrichment cone into tailings.